>
首页 » 解决方案 » NS LM5118宽电压升/降压电源方案

NS LM5118宽电压升/降压电源方案

作者:  时间:2008-09-12 11:12  来源:eaw
NS公司的LM5118是宽电压升压/降压开关电源控制器,它集成了实现高性能高性价比的降压/升压稳压器所需的所有功能,从而是外接元件数最少. LM5118的工作电压从3.5V到75V,可编程开关频率可高达到500kHz,具有可编程软起动时间,超低的关断电流和热保护等功能,具有广泛的用途.本文介绍了LM5118的主要特性,方框图以及典型的应用电路图和LM5118评估板的主要性能和详细的电路图以及所用材料清单(BOM).
The LM5118 wide voltage range Buck-Boost switching regulator controller features all of the functions necessary to implement a high performance, cost efficient Buck-Boost regulator using a minimum of external components. The Buck-Boost topology maintains output voltage regulation when the input voltage is either less than or greater than the output voltage making it especially suitable for automotive applications. The LM5118 operates as a buck regulator while the input voltage is sufficiently greater than the regulated output voltage and gradually transitions to the buck-boost mode as the input voltage approaches the output. This dual mode approach maintains regulation over a wide range of input voltages with optimal conversion efficiency in the buck mode and a glitch-free output during mode transitions. This easy to use controller includes drivers for the high side buck MOSFET and the low side boost MOSFET. The regulator’s control method is based upon current mode control utilizing an emulated current ramp. Emulated current mode control reduces noise sensitivity of the pulse-width modulation circuit, allowing reliable control of the very small duty cycles necessary in high input voltage applications. Additional protection features include current limit, thermal shutdown and an enable input. The device is available in a power enhanced TSSOP-20 package featuring an exposed die attach pad to aid thermal dissipation.
LM5118主要特性:
■ Ultra-wide input voltage range from 3V to 75V
■ Emulated peak current mode control
■ Smooth transition between step-down and step- up modes
■ Switching frequency programmable to 500KHz
■ Oscillator synchronization capability
■ Internal high voltage bias regulator
■ Integrated high and low-side gate drivers
■ Programmable soft-start time
■ Ultra low shutdown current
■ Enable input wide bandwidth error amplifier
■ 1.5% feedback reference accuracy
■ Thermal shutdown





图1.LM5118方框图和典型应用电路图



图2.12V/3A典型应用电路图
LM5118评估板
The LM5118 evaluation board is designed to provide the design engineer with a fully functional, Emulated Current Mode Control, buck-boost power converter to evaluate the LM5118 controller IC. The evaluation board provides a 12V output with 3A of output current capability. The evaluation board’s wide input voltage range is from 75V to 5V, with operation down to 3V with some component changes. The evaluation board operates at 300 kHz, a good compromise between conversion efficiency, tradeoffs between buck and buck-boost mode requirements, and converter size. The printed circuit board consists of 4 layers with 2 ounce copper top and bottom, and 1 ounce copper on internal layers. The board is constructed with FR4 material. This application note contains the evaluation
board schematic, Bill -of-Materials (BOM) and a quick setup procedure. Refer to the LM5118 data sheet and quick start for more complete circuit and design information.
LM5118 IC特性:

Integrated high and low side driver
Internal high voltage bias regulator
Ultra-wide input voltage range: 5V to 75V
Emulated current mode control
Single inductor architecture
VOUT operation below and above VIN
Single resistor sets oscillator frequency
Oscillator synchronization capability
Programmable soft-start
Ultra low (<10 μA) shutdown current
Enable input
Wide bandwidth error amplifier
Adjustable output voltage 1.23V-75V
1.5% feedback reference accuracy
Thermal Shutdown
No VIN to VOUT connection during fault protection



图3. LM5118应用框图



图4. LM5118评估板电路图

下表为LM5118评估板材料清单(BOM)


相关推荐

NS LM5118宽电压升/降压电源方案

LM5118  宽电压  升/降压电源  2009-11-06

Linear LT3598升压LED串驱动方案

LT3598  升压  LED串驱动  2009-10-29

NS LM5118宽电压升/降压电源方案

NS LM5118  宽电压  升/降压  电源  2009-05-10

如何利用降压或升压转换器优化LED照明设计

降压  升压  转换器  优化  LED  照明  2009-05-09

用全集成降/升压转换器延长锂离子电池寿命的设计

12V输入-5.2/15A输出的双相反向降压/升压电源

双相  反向  降压  升压  电源  2009-04-12
在线研讨会
焦点